Geekzone: technology news, blogs, forums
Guest
Welcome Guest.
You haven't logged in yet. If you don't have an account you can register now.




39 posts

Geek


Topic # 102734 21-May-2012 16:44 Send private message

Hey guys;

I did some wiring in the dash of my car to put in another after market headunit. Had to do all the wiring myself and used cable connectors from super cheap auto.

They are small red things and im a little worried. There is no wire exposure and i used my crimping tool to press them all down into place and its been working fine. Does any1 here think its worth wraping up the cables and separating the battery cable frm the rest to prevent any possible shorting? Imn jsut concerned it might ground itself but its highly unlikly.

Paranoid.

Here is the origional job that was done.


View this topic in a long page with up to 500 replies per page Create new topic
 1 | 2Next
13284 posts

Uber Geek

Trusted
Vodafone NZ
Subscriber

  Reply # 628453 21-May-2012 16:49 Send private message

Looks good and not much to worry about




Systems Engineer Vodafone NZ

http://forum.vodafone.co.nz



39 posts

Geek


  Reply # 628458 21-May-2012 16:58 Send private message

What I actually had to do was unplug this config and then cut all the cables in the above pic. so i could get the Soney harness in. It was a different harness and what that meant was using cable joiners.

There are no instructions on how to use cable joiners or anything.

I'll take a photo when i get the chance but i left a bit more in the way of slack on each cable to get it in.

630 posts

Ultimate Geek

Subscriber

  Reply # 628488 21-May-2012 18:18 Send private message

Looks nice.

In hindsight using heatshrink to wrap the joins would have been super cool. 
You could always gets some plumbing tape (that white stuff), and wrap your 'hot wires only' (which should only be your power, the run off to the amp and the run off to the antenna booster/expander (assuming you have one, if not highly reccomend one of these). 

448 posts

Ultimate Geek


  Reply # 628496 21-May-2012 18:37 Send private message

No need to wrap, will likely make it worse (inflexible bends etc)

Fuses are there for a reason.

gzt

3196 posts

Uber Geek

Subscriber

  Reply # 628505 21-May-2012 19:14 Send private message

what kind of crimp joins did you use exactly?



39 posts

Geek


  Reply # 628536 21-May-2012 19:50 Send private message

http://www.supercheapauto.co.nz/online-store/products/SCA-Electrical-Terminals-Cable-Joiner-Red-15-Pack.aspx?pid=120043#Description

Here is the link to the exact joiners I used to rewire the harness.

I stomped them down and did ti on my work bench and then I reattached the cables to the male->female connectors seen in the picture above.

Has anyone used thoes before?

gzt

3196 posts

Uber Geek

Subscriber

  Reply # 628567 21-May-2012 20:53 Send private message

I have used them but not that brand. If the insulation is snug against the inside then don't worry if you have done a good job. Do you know that you used the exact correct size on the crimping tool?

If they are not pulling out when you apply pressure, it is a job well done.

It is not something I do often. I did use some bad ones a long time back where the plastic insulation partially split during the crimping process.



39 posts

Geek


  Reply # 628578 21-May-2012 21:06 Send private message

Yeah thats what I found was happening or looking like it was going to happen.

It almost fractured etc.

I think they are ok honestly. But I saw a pic of a Mercialago burnt out on google and became paranoid haha...

789 posts

Ultimate Geek

Subscriber

  Reply # 628745 22-May-2012 09:33 Send private message

To be fair - if you were wiring up a Murcielago, then you'd have cause to worry - on a standard run-of-the-mill Euro...not so much.




Handsome Dan Has Spoken.

4196 posts

Uber Geek

Trusted

  Reply # 628747 22-May-2012 09:39 Send private message

Man, just wrap the 2x main battery power leads in insulation tape, put it all back together and enjoy your new head unit.

Wrap straight over the top of the connectors you have already used and start say 2cm out from the crimp connector, so you get a lot of bite on the wire itself on both sides of the connector. This will prevent it sliding off etc.

Well done on giving it a go yourself too.

14 posts

Geek


  Reply # 628749 22-May-2012 09:40 Send private message

That looks fine. Just remember, use the female connectors on the live (+) side on the car harness and male on the negative side. So if they accidentally pop out they won't short onto the metal body of the car/ stereo. Do not use Plumbers white tape as someone has suggested, Plumbers tape is for Plumbers and electrical tape is for Sparkys. Your setup looks quite safe.



39 posts

Geek


  Reply # 628768 22-May-2012 09:57 Send private message

Thanks guys I appreciate the support. Its all working fine and dandy now. I think I will jump in the back and wrap up the wires with sparky tape just to put my mind at ease.

Its not like a computer hardly any room in these damn things. Cut my hand up a bit running the RCA cables to the Amp lol.

Thanks again.



39 posts

Geek


  Reply # 629079 22-May-2012 18:33 Send private message

Ok so those connectors I have used I think are causing the headunit to restart.

Seems it'll run no problem for 30 seconds and then cut and restart.


gzt

3196 posts

Uber Geek

Subscriber

  Reply # 629081 22-May-2012 18:38 Send private message

same if you are driving or stationary?



39 posts

Geek


  Reply # 629111 22-May-2012 19:13 Send private message

Ill check.

If it happens stationary does that mean possible issue with voltage and if its moving its thoes dodgey SCA connectors?

 1 | 2Next
View this topic in a long page with up to 500 replies per page Create new topic



Twitter »
Follow us to receive Twitter updates when new discussions are posted in our forums:



Follow us to receive Twitter updates when news items and blogs are posted in our frontpage:



Follow us to receive Twitter updates when new jobs are posted to our jobs board:



Follow us to receive Twitter updates when tech item prices are listed in our price comparison site:




News »

Trending now »
Hot discussions in our forums right now:

A reason not to shop at dick smith
Created by dsnz1, last reply by AKLWestie on 17-May-2013 22:45 (82 replies)
Pages... 4 5 6


A new project coming to Geekzone
Created by freitasm, last reply by richms on 19-May-2013 11:49 (198 replies)
Pages... 12 13 14


HTC One (2013) owners' discussion
Created by Dingbatt, last reply by Finch on 19-May-2013 20:59 (1439 replies)
Pages... 94 95 96


Sitting on a boring conference call
Created by SaltyNZ, last reply by SepticSceptic on 17-May-2013 16:52 (14 replies)

Track my Phone, Car, how to best do it in .nz?
Created by DonGould, last reply by freitasm on 19-May-2013 21:26 (12 replies)

Samsung Galaxy SIII Discussion and Owners Thread
Created by networkn, last reply by Johnk on 19-May-2013 16:32 (5523 replies)
Pages... 367 368 369


Nokia Lumia 925
Created by motorwayne, last reply by Ragnor on 16-May-2013 03:04 (22 replies)
Pages... 2


Chorus is cutting the cost of VDSL to service providers from June 7
Created by maxzzz, last reply by Zeon on 19-May-2013 19:40 (46 replies)
Pages... 2 3 4



Geekzone Jobs »
Most recent NZ jobs in technology:

Exciting Intern Opportunity
Posted 19-May-2013 20:27

Business Analyst
Posted 19-May-2013 18:27

Senior Business Analyst
Posted 19-May-2013 18:27

Senior Business Analyst
Posted 19-May-2013 18:27

Project Coordinator, Reputable Company, Career Pro
Posted 19-May-2013 18:27

Change Manager - Large Financial Services Organiza
Posted 19-May-2013 18:27

Software Developer - Join a market leading company
Posted 19-May-2013 18:27


Geekzone Live »
Try automatic live updates from Geekzone directly in your browser, without refreshing the page, with Geekzone Live now.

Are you subscribed to our RSS feed? You can download the latest headlines and summaries from our stories directly to your computer or smartphone by using a feed reader.

Alternatively, you can receive a daily email with Geekzone updates.