Geekzone: technology news, blogs, forums
Guest
Welcome Guest.
You haven't logged in yet. If you don't have an account you can register now.




BDFL - Memuneh
65321 posts

Uber Geek

Administrator
Trusted
Geekzone
Lifetime subscriber

# 220389 8-Aug-2017 20:55
Send private message

The shower tray in our bathroom is cracked. Is there a way to replace just the tray, while keeping the rest of the shower? They seem to be interlocked (although not a single unit)...





Create new topic

Stu

Hammered
5327 posts

Uber Geek

Moderator
Trusted
Lifetime subscriber

  # 1841458 8-Aug-2017 20:57
Send private message

Normally the tray goes down first, and then everything else on top of that. Would think it would be rather difficult to simply replace the tray unfortunately. If you can get the rest of the panels (if acrylic) out in one piece, you may be able to reinstall after replacing the tray. Best of luck!





Keep calm, and carry on posting.

 

 

 

Click to see full size Click to see full size


262 posts

Ultimate Geek


  # 1841460 8-Aug-2017 20:59
Send private message

Is it white acrylic base and lining? If so, the whole thing will need to come out because there is a small 10-20mm lip up behind the liner that will be fully siliconed in.


 
 
 
 




BDFL - Memuneh
65321 posts

Uber Geek

Administrator
Trusted
Geekzone
Lifetime subscriber

  # 1841461 8-Aug-2017 20:59
Send private message

Yes, thought so. I don't think there's an easy way of removing the tray without taking the panels out, which would probably mean replacing them...





22896 posts

Uber Geek

Trusted
Subscriber

  # 1841462 8-Aug-2017 21:00
Send private message

If it was from something falling on it and cracking it then it may be an insurance thing you can look into.





Richard rich.ms

Mad Scientist
21329 posts

Uber Geek

Trusted
Lifetime subscriber

  # 1841483 8-Aug-2017 21:36
Send private message

And with a bit of luck, no excess on bathroom bits ...





Involuntary autocorrect in operation on mobile device. Apologies in advance.


400 posts

Ultimate Geek


  # 1841498 8-Aug-2017 23:12
Send private message

Our shower tray in our ensuite cracked a year ago, guy came around to check said no way it's repairable, although there are acrylic repair kits you can buy but would depend on severity of crack - ours was well gone, apparently never put in properly, floor under soggy, particleboard had turned to weetbix, ended up doing an insurance claim ($400 excess) guy put in new ply floor, replaced tray and liner, used existing glass sides, walls repainted and tiled floor running up to tray fixed up.

Do it once, do it properly! Half arsed repair jobs never last




 

 


1199 posts

Uber Geek
Inactive user


  # 1841595 9-Aug-2017 08:30
Send private message

Complete new Showers including trays are pretty cheap these days. It may be tempting to just go out and get a whole new thing.

 

But most of the cheap ones mean built cheap, and you may end up having the same thing happen in a couple of years. It is my understanding that the showers with plastic trays (complete units) can be put in without building consent. This may be why they so popular.

 

I can't handle the plastic, not only can they crack, they scratch too, and after a few years can start looking dirty.

 

If I was redoing my shower today I would probably opt for a stainless steel type. They old fashioned, but they will last a lifetime. Otherwise even better, if your house is on a concrete slab, get it done professionally out of concrete & tile.


 
 
 
 




BDFL - Memuneh
65321 posts

Uber Geek

Administrator
Trusted
Geekzone
Lifetime subscriber

1094 posts

Uber Geek


  # 1841622 9-Aug-2017 09:38
Send private message

Is there an issue with tiling in a wooden framed house?


2082 posts

Uber Geek

Subscriber

  # 1841632 9-Aug-2017 09:56
Send private message

Don't want to depress you, but I had a similar experience as chimera. Floor replacement job plus wall re-lining with moisture proof plaster board. 

 

At least the leak into the ceiling in the room below stopped!


2523 posts

Uber Geek

Lifetime subscriber

  # 1841642 9-Aug-2017 10:11
Send private message

Our recent refurb included three bathrooms in a timber frame/brick veneer house. Two upstairs on timber floors required a waterproof membrane system, with the shower drain designed as the lowest point in a sill-less shower. The third bathroom, was on the ground floor concrete slab so the shower couldn't be built lower than the floor. It also required a waterproof membrane, but also had a floor drain in addition to the shower drain and the shower has a sill.

 

They're pretty strict now days on the design and certification.

 

 


649 posts

Ultimate Geek


  # 1841644 9-Aug-2017 10:14
Send private message

I was in a similar situation last year, tried to get the tray only replaced but didn't have much luck finding the size and they were saying liner has to come off too and there is a risk of liner breaking etc and finding the exact size and type tray was also a challenge.  Ended up buying a Clearlite Sierra Shower, changed all the plumbing and waste had to be moved too as i got a slightly bigger shower. Also, GIB had to be replaced when liner was pulled, go with Aqualine GIB only.  One more thing, make sure the installer cleans the base before putting the tray and the area around the waste is packed properly using concrete not loose rocks etc. or gap 7.
Getting tray installation right is more important I think. 

 

Total cost ended up roughly $3000 I think. Only thing which is a bit of hassle is coordinating with different tradies, plumber,builder type of person to do the GIB etc and the shower installer then again plumber to put fittings back. Other option was bit expensive to contact someone who can do everything like some shower installers supply and install but maybe worth it as I found this process full of stress and time taking. Shower was this one http://www.trademe.co.nz/building-renovation/other/auction-1389871379.htm but you can get it for a better price. 

 

I've learnt it's all about getting the right installer but can be challenging as they want a plumber to do the tray.


Create new topic



Twitter and LinkedIn »



Follow us to receive Twitter updates when new discussions are posted in our forums:



Follow us to receive Twitter updates when news items and blogs are posted in our frontpage:



Follow us to receive Twitter updates when tech item prices are listed in our price comparison site:





News »

Ring launches indoor-only security camera
Posted 23-Jan-2020 17:26


New report findings will help schools implement the digital technologies curriculum content
Posted 23-Jan-2020 17:25


N4L to upgrade & support wireless internet inside schools
Posted 23-Jan-2020 17:22


Netflix releases 21 Studio Ghibli works
Posted 22-Jan-2020 11:42


Vodafone integrates eSIM into device and wearable roadmap
Posted 17-Jan-2020 09:45


Do you need this camera app? Group investigates privacy implications
Posted 16-Jan-2020 03:30


JBL launches headphones range designed for gaming
Posted 13-Jan-2020 09:59


Withings introduces ScanWatch wearable combining ECG and sleep apnea detection
Posted 9-Jan-2020 18:34


NZ Police releases public app
Posted 8-Jan-2020 11:43


Suunto 7 combine sports and smart features on new smartwatch generation
Posted 7-Jan-2020 16:06


Intel brings innovation with technology spanning the cloud, network, edge and PC
Posted 7-Jan-2020 15:54


AMD announces high performance desktop and ultrathin laptop processors
Posted 7-Jan-2020 15:42


AMD unveils four new desktop and mobile GPUs including AMD Radeon RX 5600
Posted 7-Jan-2020 15:32


Consolidation in video streaming market with Spark selling Lightbox to Sky
Posted 19-Dec-2019 09:09


Intel introduces cryogenic control chip to enable quantum computers
Posted 10-Dec-2019 21:32



Geekzone Live »

Try automatic live updates from Geekzone directly in your browser, without refreshing the page, with Geekzone Live now.


Support Geekzone »

Our community of supporters help make Geekzone possible. Click the button below to join them.

Support Geezone on PressPatron



Are you subscribed to our RSS feed? You can download the latest headlines and summaries from our stories directly to your computer or smartphone by using a feed reader.

Alternatively, you can receive a daily email with Geekzone updates.